Opel Zafira C Tourer (2012-2018) uses fuse boxes in the engine compartment, behind the driver’s dashboard compartment and behind the left luggage trim. The full 2012 diagram differs from the electrical scheme introduced in 2013; later LED headlights, diesel SCR/NOx equipment and trim options add more variation. This guide contains 249 entries across ten complete source tables, with original schematics, rather than treating the separate 2014-2015 Zafira Tourer guide as valid across all production years. No amperage is guessed for charts where the original does not state it.
Where are the Zafira Tourer fuse boxes?
Switch off the ignition. Open the engine fuse box at the front left under the bonnet by releasing the retaining clips. On left-hand-drive vehicles, open and carefully lower the driver’s small dashboard storage compartment to access the interior fuses; right-hand-drive Vauxhall versions may have their access behind the glovebox. Remove the left luggage trim access cover, moving the tyre repair kit container if necessary.
Commonly checked fuse positions
| Pozycja | Amperaż [A] | Chroniony obwód / funkcja |
|---|---|---|
| Cabin F6 | – | Cigarette lighter / front 12 V socket |
| Cabin F7 | – | Additional 12 V outlet |
| Cabin F16 / luggage F17 | – | Luggage-area 12 V outlet |
| Engine F49 | – | Fuel pump |
| Engine F47 | – | Horn |
| Engine F14 | – | Rear window wiper |
| Engine F43-F44 | – | Front windscreen wipers |
| Engine F18 | – | Heated rear window |
Zafira C Tourer 2012 engine fuses F1-F54
The 2012 chart leaves F13 unused, assigns F21 to ABS, F31 to Start/Stop, adaptive cruise and auxiliary heating, and F34 to the coolant pump. Wipers are at F43/F44 (front) and F14 (rear), starter at F16, horn at F47 and fuel pump at F49. These are source positions, not guaranteed current ratings.
| Pozycja | Amperaż [A] | Chroniony obwód / funkcja |
|---|---|---|
| 1 | – | Engine control module |
| 2 | – | Oxygen/lambda sensor |
| 3 | – | Fuel injection and ignition system |
| 4 | – | Fuel injection and ignition system |
| 5 | – | Unused position |
| 6 | – | Heated exterior mirrors |
| 7 | – | Radiator fan control |
| 8 | – | Lambda sensor and engine |
| 9 | – | Rear window sensor |
| 10 | – | Battery condition / voltage sensor |
| 11 | – | Tailgate release |
| 12 | – | Adaptive Forward Lighting (AFL) module |
| 13 | – | Unused position |
| 14 | – | Rear window wiper |
| 15 | – | Engine control module |
| 16 | – | Starter motor |
| 17 | – | Transmission control module |
| 18 | – | Heated rear window |
| 19 | – | Front electric windows |
| 20 | – | Rear electric windows |
| 21 | – | ABS controller |
| 22 | – | Left halogen high-beam headlamp |
| 23 | – | Headlamp washers |
| 24 | – | Right xenon dipped-beam headlamp |
| 25 | – | Left xenon dipped-beam headlamp |
| 26 | – | Front fog lamps |
| 27 | – | Diesel fuel heating |
| 28 | – | Start/Stop system |
| 29 | – | Electronic parking brake |
| 30 | – | ABS hydraulic supply |
| 31 | – | Start/Stop, adaptive cruise control and auxiliary heating |
| 32 | – | Airbag controller |
| 33 | – | Adaptive front lighting and automatic headlamp control |
| 34 | – | Coolant circulation pump |
| 35 | – | Electric windows |
| 36 | – | Air-conditioning compressor |
| 37 | – | Fuel vapour canister vent solenoid |
| 38 | – | Vacuum pump |
| 39 | – | Fuel control module |
| 40 | – | Front and rear washer pumps |
| 41 | – | Right halogen high-beam headlamp |
| 42 | – | Radiator cooling fan |
| 43 | – | Front windscreen wiper |
| 44 | – | Wiper system |
| 45 | – | Radiator cooling fan, additional circuit |
| 46 | – | Unused position |
| 47 | – | Horn |
| 48 | – | Radiator cooling fan, high-current circuit |
| 49 | – | Fuel pump |
| 50 | – | Headlamp levelling and adaptive lighting |
| 51 | – | Active air intake shutter |
| 52 | – | Diesel auxiliary heater |
| 53 | – | Transmission and engine controllers |
| 54 | – | Electrical-system monitoring |
Zafira C Tourer 2013-on revised engine fuses F1-F54
In the revised layout F13 protects ABS, F21 serves rear electrical distribution and F34 protects EGR. The physical fuse pattern may be similar, but the assignments are not identical. Check the vehicle’s production date.
| Pozycja | Amperaż [A] | Chroniony obwód / funkcja |
|---|---|---|
| 1 | – | Engine control module |
| 2 | – | Oxygen/lambda sensor |
| 3 | – | Fuel injection and ignition system |
| 4 | – | Fuel injection and ignition system |
| 5 | – | Unused position |
| 6 | – | Heated door mirrors and alarm |
| 7 | – | Cooling fan, engine and transmission control |
| 8 | – | Lambda sensor and engine cooling |
| 9 | – | Rear window sensor |
| 10 | – | Battery condition / voltage sensor |
| 11 | – | Tailgate release |
| 12 | – | Adaptive lighting and automatic headlights |
| 13 | – | ABS controller or associated supply, rating unspecified |
| 14 | – | Rear window wiper |
| 15 | – | Engine control module |
| 16 | – | Starter motor |
| 17 | – | Transmission control module |
| 18 | – | Heated rear window |
| 19 | – | Front electric windows |
| 20 | – | Rear electric windows |
| 21 | – | Rear electrical centre |
| 22 | – | Left halogen high-beam headlamp |
| 23 | – | Headlamp washers |
| 24 | – | Right xenon dipped-beam headlamp |
| 25 | – | Left xenon dipped-beam headlamp |
| 26 | – | Front fog lamps |
| 27 | – | Diesel fuel heating |
| 28 | – | Start/Stop system |
| 29 | – | Electronic parking brake |
| 30 | – | ABS hydraulic supply |
| 31 | – | Adaptive cruise control |
| 32 | – | Airbag controller |
| 33 | – | Adaptive front lighting and automatic headlamps |
| 34 | – | Exhaust gas recirculation EGR |
| 35 | – | Door mirrors and rain sensor |
| 36 | – | Air-conditioning control |
| 37 | – | Evaporative emission control purge valve |
| 38 | – | Vacuum pump |
| 39 | – | Central control module |
| 40 | – | Front and rear washer pumps |
| 41 | – | Right halogen high-beam headlamp |
| 42 | – | Radiator cooling fan |
| 43 | – | Front windscreen wiper |
| 44 | – | Front windscreen wiper, second circuit |
| 45 | – | Radiator cooling fan, additional circuit |
| 46 | – | Unused position |
| 47 | – | Horn |
| 48 | – | Radiator cooling fan, high-current circuit |
| 49 | – | Fuel pump |
| 50 | – | Headlamp levelling and AFL |
| 51 | – | Air intake shutter |
| 52 | – | Diesel auxiliary heater |
| 53 | – | Transmission and engine controllers |
| 54 | – | Vacuum pump, instrument cluster, heating, ventilation and air conditioning |
Engine compartment relays
Starter K2, engine control K3, heated rear glass K4, headlamp washer K5, fuel module K7 and fuel heater K9.
| Pozycja | Amperaż [A] | Chroniony obwód / funkcja |
|---|---|---|
| K2 | – | Starter relay K2 |
| K3 | – | Engine management relay K3 |
| K4 | – | Heated rear-window relay K4 |
| K5 | – | Headlamp-washer pump relay K5 |
| K7 | – | Fuel supply / fuel pump module relay K7 |
| K9 | – | Fuel preheating relay K9 |
High-current main fuses above the engine electrical box
F5 (80 A) diesel glow control, F6 (80 A) electric power steering, F7 (100 A) optional PTC heater, F8 (80 A) radiator cooling fan. Treat bolted high-current fuses differently from ordinary blade fuses.
| Pozycja | Amperaż [A] | Chroniony obwód / funkcja |
|---|---|---|
| F5 | 80 | Diesel glow-plug controller |
| F6 | 80 | Electric power steering main supply |
| F7 | 100 | Electric PTC supplementary cabin heater |
| F8 | 80 | Radiator cooling fan main supply |
Dashboard fuse chart – 2012
Cigarette lighter at F6, additional 12 V outlet F7, luggage socket feed F16, radio F4, blower F11 and Start/Stop at F18. Do not infer other model-year ratings.
| Pozycja | Amperaż [A] | Chroniony obwód / funkcja |
|---|---|---|
| 1 | – | Cruise control, speed limiter, adaptive cruise control and steering-wheel controls |
| 2 | – | Body control module |
| 3 | – | Body control module |
| 4 | – | Radio |
| 5 | – | Infotainment and instrument cluster |
| 6 | – | Cigarette lighter / 12 V outlet |
| 7 | – | Additional 12 V power outlet |
| 8 | – | Body control module |
| 9 | – | Airbag module |
| 10 | – | Body control module |
| 11 | – | Cabin blower / air conditioning |
| 12 | – | Unused position |
| 13 | – | Unused position |
| 14 | – | Diagnostic socket |
| 15 | – | Airbag control system, rating unspecified |
| 16 | – | Luggage area power outlet |
| 17 | – | Air-conditioning system |
| 18 | – | Start/Stop |
| 19 | – | Brake lights, rear lamps and interior lighting |
| 20 | – | Body control module |
| 21 | – | Instrument cluster |
| 22 | – | Ignition switch |
| 23 | – | Body control module |
| 24 | – | Body control module |
| 25 | – | Unused position |
| 26 | – | Unused position |
Dashboard fuse chart – revised 2013-on layout
F18 changes to the transport/logistics mode in this source, with further differences involving exterior lighting and Body Control Module supplies.
| Pozycja | Amperaż [A] | Chroniony obwód / funkcja |
|---|---|---|
| 1 | – | Cruise control, speed limiter, adaptive cruise control and steering-wheel controls |
| 2 | – | Exterior lights and body module |
| 3 | – | Exterior lights and body module |
| 4 | – | Infotainment |
| 5 | – | Infotainment and instrument cluster |
| 6 | – | Cigarette lighter and front 12 V power outlet |
| 7 | – | Additional 12 V power outlet |
| 8 | – | Left low beam / body module |
| 9 | – | Right low beam, body and airbag modules |
| 10 | – | Door locks / body module |
| 11 | – | Cabin blower |
| 12 | – | Unused position |
| 13 | – | Unused position |
| 14 | – | Diagnostic port |
| 15 | – | Airbag control system, rating unspecified |
| 16 | – | Additional power outlet |
| 17 | – | Air-conditioning system |
| 18 | – | Transport and logistics supply mode |
| 19 | – | Body control module |
| 20 | – | Body control module |
| 21 | – | Instrument cluster and theft alarm |
| 22 | – | Ignition sensor |
| 23 | – | Body control module |
| 24 | – | Body control module |
| 25 | – | Unused position |
| 26 | – | Unused position |
Luggage fuse box – 2012 layout
Optional trailer control at F1, theft alarm F8, heated wheel F19, sunroof/sunshade F20, seat heating F21, amplifier F31 and adaptive suspension F32. The early chart does not yet assign later diesel SCR/NOx functions to F4/F9/F10/F24.
| Pozycja | Amperaż [A] | Chroniony obwód / funkcja |
|---|---|---|
| 1 | – | Trailer control module |
| 2 | – | Trailer connector |
| 3 | – | Parking assistance |
| 4 | – | Unused position |
| 5 | – | Unused position |
| 6 | – | Unused position |
| 7 | – | Powered front seat |
| 8 | – | Theft alarm |
| 9 | – | Unused position |
| 10 | – | Unused position |
| 11 | – | Trailer module and trailer connector |
| 12 | – | Unused position |
| 13 | – | Trailer connector |
| 14 | – | Unused position |
| 15 | – | Folding mirrors, rain sensor and automatic high-beam assist |
| 16 | – | Rear-view mirror |
| 17 | – | Luggage compartment 12 V power outlet |
| 18 | – | Unused position |
| 19 | – | Heated steering wheel |
| 20 | – | Sunroof or rear sunshade |
| 21 | – | Heated seats |
| 22 | – | Unused position |
| 23 | – | Unused position |
| 24 | – | Unused position |
| 25 | – | Adaptive cruise control and blind-spot monitoring |
| 26 | – | Unused position |
| 27 | – | Unused position |
| 28 | – | Unused position |
| 29 | – | Unused position |
| 30 | – | Unused position |
| 31 | – | Audio amplifier and subwoofer |
| 32 | – | Active damping and lane-departure warning |
Revised luggage fuse panel – 2013 onward
SCR/NOx emission control circuits are fitted on appropriate later diesels; unused spaces and market-specific options remain shown in full.
| Pozycja | Amperaż [A] | Chroniony obwód / funkcja |
|---|---|---|
| 1 | – | Unused position |
| 2 | – | Trailer connector |
| 3 | – | Parking assistance |
| 4 | – | Selective Catalytic Reduction (SCR) exhaust-treatment system, diesel |
| 5 | – | Unused position |
| 6 | – | Unused position |
| 7 | – | Power-adjustable seat |
| 8 | – | Unused position |
| 9 | – | SCR system, diesel |
| 10 | – | NOx nitrogen oxides sensor, diesel |
| 11 | – | Trailer module and trailer connector |
| 12 | – | Trailer control module |
| 13 | – | Trailer connector |
| 14 | – | Unused position |
| 15 | – | Unused position |
| 16 | – | Interior rear-view mirror and reversing camera, if fitted |
| 17 | – | Luggage compartment 12 V power outlet |
| 18 | – | Unused position |
| 19 | – | Heated steering wheel |
| 20 | – | Rear sunblind or sunscreen |
| 21 | – | Heated front seats |
| 22 | – | Unused position |
| 23 | – | Unused position |
| 24 | – | SCR exhaust-treatment system, diesel |
| 25 | – | Unused position |
| 26 | – | Unused position |
| 27 | – | Unused position |
| 28 | – | Unused position |
| 29 | – | Unused position |
| 30 | – | Unused position |
| 31 | – | Unused position |
| 32 | – | Adaptive damping and lane-departure warning |
2012 versus 2013 and later fuse assignments
Engine F13, F21, F23-F25 and F34, along with SCR/NOx circuits in the luggage panel, require model-year-specific checks.
| Pozycja | Amperaż [A] | Chroniony obwód / funkcja |
|---|---|---|
| Engine F13 | – | Engine F13: unused in 2012, ABS from 2013 |
| Engine F21 | – | Engine F21: ABS in 2012, rear electrical distribution from 2013 |
| Engine F23 | – | Engine F23: headlamp washers in 2012/2013, unused on certain later versions |
| Engine F24 | – | Engine F24: right xenon dipped beam in 2012/2013, right LED headlamp in some later configurations |
| Engine F25 | – | Engine F25: left xenon dipped beam in 2012/2013, left LED headlamp in some later configurations |
| Engine F34 | – | Engine F34: coolant circulation pump in 2012, EGR on revised installations |
| Rear F4/F9/F10/F24 | – | Rear F4/F9/F10/F24: no SCR/NOx module in 2012; diesel SCR/NOx circuits on relevant later vehicles |
Zafira Tourer fuse box FAQ
Which fuse protects the cigarette lighter?
Dashboard F6 in the documented installations. The 2014-2015 guide identifies 20 A for its specific version; consult the actual vehicle’s fuse legend.
Why does the 2012 chart not match a 2013 vehicle?
Electrical supply assignments changed, especially F13 and F21, while diesel emissions and lighting equipment can also vary.
Which fuse is for electric steering?
Main F6 (80 A) in the documented power distribution block.
The older Opel Zafira B uses entirely different A/B fuse layouts. Always replace a fuse with the exact manufacturer-specified current and type.