Volvo S60 II (2011-2018) has a main engine compartment fuse box, two modules A and B beneath the front passenger glovebox, and a rear luggage compartment unit. Some Start/Stop versions also have a supplementary high-current panel. This guide retains all 166 original fuse table rows in six tables, including unused and variant-specific entries.
Do not confuse additional table rows with additional physical sockets: the engine box has 44 numbered positions but 60 source rows because some positions use different ratings or consumers by engine, equipment or production year. For the early production configuration, see the Volvo S60 II 2010-2011 fuse box diagrams. Always check the original vehicle fuse diagram and the installed fuse rating.
Where are the Volvo S60 II fuse boxes?
Under the bonnet: the main power distribution box for the engine, ABS, steering, wipers, HVAC and other circuits. Under the passenger glovebox: two separate modules A and B, with changes from 2011 to the 2012-2018 arrangement. In the boot: a side-panel fuse block supplying the electric parking brake, heated rear window, trailer and 12 V power. A further high-current block exists on some Start/Stop cars.
Engine compartment fuse box: 44 numbered positions
Position 9 (30 A) supplies front wipers, 11 (40 A) the climate blower, 13 (40 A) the ABS pump, 14 (20 A) the ABS valves and 29 (15 A) the horn. The engine control positions 30 and 35-44 have multiple petrol and diesel variations and must be matched to the correct engine.
| Position | Rating [A] | Protected circuit / function |
|---|---|---|
| 1 | 50 | Main CEM supply KL30B |
| 2 | 50 | Main CEM supply KL30A |
| 3 | 60 | Rear Junction Box RJBA supply KL30 |
| 4 | 60 | Cabin Junction Box CJB supply KL30 |
| 5 | 60 | Additional cabin distribution feed CJB 15E/KL30 |
| 6 | – | Unused |
| 7 | 100 | Electric PTC air heater |
| 8 | 20 | 2011-2013 headlamp washers |
| 8 (variant 2) | 40 | 2014-2018 left heated windscreen; fuse 8 alternate |
| 9 | 30 | Front windscreen wipers |
| 10 | 25 | Parking heater |
| 11 | 40 | Climate-control blower |
| 12 | 40 | 2014-2018 right heated windscreen |
| 13 | 40 | ABS pump |
| 14 | 20 | ABS valves |
| 15 | 20 | 2014-2018 headlamp washers |
| 16 | 10 | Headlamp levelling and ABL |
| 17 | 20 | Central Electronic Module main feed |
| 18 | 5 | ABS switched power |
| 19 | 5 | Speed-sensitive power steering |
| 20 | 10 | ECM, TCM and SRS electronics |
| 21 | 10 | Heated washer nozzles |
| 22 | 5 | 2011-2012 turbo petrol vacuum pump |
| 23 | 5 | Lighting control panel |
| 24 | – | Unused |
| 25 | – | Unused |
| 26 | – | Unused |
| 27 | 5 | Engine compartment relay |
| 28 | 20 | Optional auxiliary lights |
| 29 | 15 | Horn |
| 30 | 10 | ECM standard 2011-2018 |
| 30 (variant 2) | 5 | 2016-2018 four-cylinder ECM; 5 A alternate for fuse 30 |
| 31 | 15 | Automatic transmission module |
| 32 | 15 | 2011-2016 A/C compressor; 2012-2018 diesel supplementary coolant pump |
| 33 | 5 | Relay coils |
| 34 | 30 | 2011-2016 starter relay |
| 35 | 10 | Four-cylinder petrol ignition coils or five-cylinder diesel glow controller |
| 35 (variant 2) | 20 | Four-cylinder ECM, five-/six-cylinder petrol ignition coils and capacitor |
| 36 | 10 | Petrol ECM: 2011-2013; 2014-2015 petrol apart from specified 2.0 L/B4204T7; 2016 five-/six-cylinder |
| 36 (variant 2) | 15 | Diesel ECM: 2011-2013; 2014-2015 1.6 L or five-cylinder; 2016-2018 five-cylinder, 15 A variant |
| 36 (variant 3) | 20 | 2014-2018 four-cylinder ECM; alternative 20 A for 2.0 L petrol version |
| 37 | 15 | 2011-2016 airflow sensor, diesel solenoids, petrol injectors and ECM on five-/six-cylinder engines; 2017-2018 diesel MAF/valves |
| 37 (variant 2) | 10 | 2012-2015 1.6 L petrol and D4162T airflow and fuel-flow control; 2014-2018 2.0 L four-cylinder thermostat, EVAP and EGR cooling, 10 A variant |
| 38 | 10 | 2011-2018 engine valves, A/C clutch, airflow, intake actuators and oil-level sensors by year and petrol/diesel engine |
| 38 (variant 2) | 15 | 2014-2018 four-cylinder engine valves, oil pump and oxygen sensors, 15 A alternate |
| 39 | 15 | 2011-2018 petrol EVAP, lambda sensors, injectors and diesel radiator shutter where specified |
| 39 (variant 2) | 10 | 2011-2015 four-cylinder petrol and diesel oxygen sensors and five-cylinder diesel radiator shutter, 10 A alternate |
| 40 | 20 | 2011 petrol vacuum pump and crankcase valve; 2012 petrol breather or diesel fuel heater; 2013-2018 diesel filter heater |
| 40 (variant 2) | 10 | 2012-2016 Start/Stop coolant pump, crankcase heater or automatic gearbox oil pump, 10 A alternate |
| 40 (variant 3) | 15 | 2014-2018 four-cylinder petrol ignition coils, 15 A alternate |
| 41 | 5 | 2011 five-cylinder diesel crankcase ventilation heater; 2013-2016 petrol radiator shutter |
| 41 (variant 2) | 10 | 2012-2018 five-cylinder diesel breather heater and Start/Stop gearbox oil pump |
| 41 (variant 3) | 15 | 2014-2015 four-cylinder diesel A/C clutch, glow controller and oil pump, 15 A alternate |
| 41 (variant 4) | 7.5 | 2015-2018 four-cylinder A/C clutch, diesel glow controller and oil pump, 7.5 A alternate |
| 42 | 70 | Diesel glow plugs, 70 A |
| 42 (variant 2) | 50 | 2014-2018 four-cylinder petrol coolant pump, 50 A alternate |
| 43 | 60 | 2011-2018 radiator cooling fan, 60 A petrol configuration |
| 43 (variant 2) | 80 | 2011-2018 radiator cooling fan, 80 A six-cylinder petrol or diesel configuration |
| 44 | 80 | 2011 1.6 diesel electrohydraulic steering, 80 A |
| 44 (variant 2) | 100 | 2011 other engines and 2012-2018 power steering, 100 A |
Equipment differences can move headlamp washer and heated windscreen functions between positions 8, 12 and 15. Diesel glow plugs and several powertrain sensors have model-year dependent ratings, so do not replace fuses using a different engine’s amperage.
Passenger fuse box A
Fuse box A protects door modules, electric and heated seats, factory audio, Keyless equipment and optional AWD. Fuse 22 (15 A) is used for the center-console 12 V socket in the later layout. AWD fuse position 29 is rated 10 A in 2011-2012 and 15 A in 2013-2018 on equipped cars.
| Position | Rating [A] | Protected circuit / function |
|---|---|---|
| 1 | 40 | Main audio system supply and positions 16-20 |
| 2 | 25 | 2015-2018 front windscreen washer |
| 3 | – | Unused |
| 4 | – | Unused |
| 5 | – | Unused |
| 6 | 5 | Optional Keyless door handles |
| 7 | – | Unused |
| 8 | 20 | Driver door electronic module |
| 9 | 20 | Front passenger door module |
| 10 | 20 | Right rear door module |
| 11 | 20 | Left rear door module |
| 12 | 7.5 | Keyless access |
| 13 | 20 | Driver power seat |
| 14 | 20 | Front passenger power seat |
| 15 | 15 | 2011-2012 folding headrests |
| 16 | 5 | Infotainment control module or display |
| 17 | 10 | 2011 radio, display and RTI; 2012-2018 audio amplifier, digital TV/radio |
| 18 | 15 | 2011 infotainment; 2012-2018 audio or Sensus module |
| 19 | 5 | Telephone and Bluetooth |
| 20 | – | Unused |
| 21 | 5 | Sunroof, roof lighting, climate sensor and air-flap motors |
| 22 | 15 | 2011 cigarette lighter/rear seat entertainment; 2012-2018 center-console 12 V socket |
| 23 | 15 | Heated front passenger seat |
| 24 | 15 | Heated driver seat |
| 25 | – | Unused |
| 26 | 15 | Right rear heated seat |
| 27 | 15 | Left rear heated seat |
| 28 | 5 | Parking sensors, reversing camera, navigation and BLIS |
| 29 | 10 | 2011-2012 AWD controller |
| 29 (variant 2) | 15 | 2013-2018 AWD controller, 15 A alternative to the same position 29 |
| 30 | 10 | Four-C active chassis |
Passenger fuse box B: 2011
The early panel B includes lighting, SRS, the fuel pump, steering security and washers. Fuel pump position 13 (20 A) and the alarm/OBD II circuit 16 (5 A) are individually described. The table retains all unused slots and original rating values.
| Position | Rating [A] | Protected circuit / function |
|---|---|---|
| 1 | – | Unused |
| 2 | – | Unused |
| 3 | 7.5 | Interior lighting and driver seat controls |
| 4 | 5 | Driver Information Module (DIM) |
| 5 | 10 | Adaptive cruise control and collision warning |
| 6 | 7.5 | Interior lighting and rain sensor |
| 7 | 7.5 | Steering wheel electronics |
| 8 | 10 | Rear central locking and fuel filler flap |
| 9 | 15 | Washer circuit |
| 10 | 15 | Front windscreen washers |
| 11 | 10 | Boot lid release |
| 12 | 10 | No specific function listed; 10 A is given |
| 13 | 20 | Fuel pump |
| 14 | 5 | Remote receiver, alarm and climate controls |
| 15 | 15 | Steering column locking |
| 16 | 5 | Alarm and OBD II diagnostics |
| 17 | – | Unused |
| 18 | 10 | SRS airbag system |
| 19 | 5 | Front collision radar |
| 20 | 7.5 | Accelerator pedal, diesel auxiliary heater, optional electric mirrors and heated rear seats |
| 21 | 15 | Infotainment module, CD player and radio |
| 22 | 5 | Brake warning indicator |
| 23 | 20 | Sunroof |
| 24 | 5 | Immobiliser |
Passenger fuse box B: 2012-2018
In the later panel, position 9 (15 A) can serve a heated steering wheel in 2014-2018, while position 10 (15 A) changes from windscreen washers to heated windscreen equipment. The fuel pump remains position 13 (20 A) in this reference and alarm/OBD II remains 16 (5 A).
| Position | Rating [A] | Protected circuit / function |
|---|---|---|
| 1 | – | Unused |
| 2 | – | Unused |
| 3 | 7.5 | Interior lights, power seats, driver door windows and optional garage-door opener |
| 4 | 5 | 2012-2013 instrument display DIM; 2014-2018 integrated instrument cluster |
| 5 | 10 | Adaptive cruise control and collision warning |
| 6 | 7.5 | Interior lighting and rain sensor |
| 7 | 7.5 | Steering wheel module |
| 8 | 10 | Central locking and fuel filler flap |
| 9 | 15 | 2014-2018 heated steering wheel |
| 10 | 15 | 2012-2013 windscreen washers; 2014-2018 heated windscreen |
| 11 | 10 | Boot lid release |
| 12 | 10 | 2013-2018 folding rear headrests |
| 13 | 20 | Fuel pump |
| 14 | 5 | Alarm motion sensor and climate controller |
| 15 | 15 | Steering column locking |
| 16 | 5 | Alarm siren and OBD II diagnostic connector |
| 17 | – | Unused |
| 18 | 10 | SRS airbags |
| 19 | 5 | Collision warning system |
| 20 | 7.5 | Accelerator pedal, auto-dimming mirror, rear heated seats and auxiliary heater |
| 21 | 15 | 2014-2018 Performance infotainment and audio control |
| 22 | 5 | Brake warning lamp |
| 23 | 20 | Electric sunroof |
| 24 | 5 | Immobiliser |
Rear luggage compartment fuse box
The electric parking brake uses independent circuits at 1 and 2 (30 A each). The heated rear window is 3 (30 A), optional cargo outlet 6 (15 A), and primary trailer electrical supply 11 (40 A). Unassigned positions are preserved.
| Position | Rating [A] | Protected circuit / function |
|---|---|---|
| 1 | 30 | Left electric parking brake |
| 2 | 30 | Right electric parking brake |
| 3 | 30 | Heated rear window |
| 4 | 15 | Second trailer connector/feed |
| 5 | – | Unused |
| 6 | 15 | Boot 12 V outlet |
| 7 | – | Unused |
| 8 | – | Unused |
| 9 | – | Unused |
| 10 | – | Unused |
| 11 | 40 | Main trailer supply |
| 12 | – | Unused |
Start/Stop additional power distribution unit
On fitted vehicles, A1 and A2 are 175 A each, fuse 11 (70 A) supplies the auxiliary battery, and position 12 is 15 A in 2012-2015 or 5 A in 2016-2018 for the CEM reference circuit. These are separate variants of the same position. High-current MEGA/MIDI protection should be examined and replaced by qualified service personnel.
| Position | Rating [A] | Protected circuit / function |
|---|---|---|
| A1 | 175 | Main engine-bay electrical distribution |
| A2 | 175 | Main CEM, cabin fuse and rear electrical distribution feeds |
| 1 | 100 | Supplementary electric heater |
| 2 | 50 | CEM main supply beneath glovebox |
| 3 | 60 | Cabin fuse/relay distribution |
| 4 | 60 | 2012-2015 cabin box A supply; 2016-2018 heated windscreen |
| 5 | 60 | Rear cargo distribution supply |
| 6 | 40 | Climate blower |
| 7 | – | Unused |
| 8 | – | Unused |
| 9 | 30 | Starter relay |
| 10 | 50 | 2012-2015 internal diode |
| 11 | 70 | Auxiliary battery |
| 12 | 15 | 2012-2015 CEM reference voltage, auxiliary battery 15 A |
| 12 (variant 2) | 5 | 2016-2018 CEM reference voltage, auxiliary battery 5 A alternate to fuse 12 |
Volvo S60 II: cigarette lighter, wipers, OBD, ABS and AWD
Console 12 V socket: fuse A22 (15 A). Luggage 12 V outlet: rear panel 6 (15 A). Front wipers: engine fuse 9 (30 A). Horn: engine fuse 29 (15 A). Heater blower: engine fuse 11 (40 A).
OBD II diagnostics: passenger panel B16 (5 A). Fuel pump: B13 (20 A). ABS: engine 13 (40 A) and 14 (20 A). AWD: panel A29, 10 A in 2011-2012 or 15 A from 2013, if equipped.
Other Volvo sedans and wagons have different fuse assignments. See the Volvo XC70 II / V70 III (2007-2016) and Volvo S40 II (2012) for their own separate diagrams.
Volvo S60 II fuse box FAQ
Where is the passenger compartment fuse box?
Below the passenger glovebox; two independent modules A and B can be fitted.
Which fuse protects the cigarette lighter?
Passenger box A position 22 (15 A) for the console 12 V socket in the reference layout.
Which fuse protects the windscreen wipers?
Engine compartment position 9 (30 A).
Is Start/Stop fuse 12 the same for every model year?
No. The source lists 15 A in 2012-2015 and 5 A in 2016-2018 for the auxiliary battery reference circuit.
Why are there more table rows than fuse numbers?
Several entries describe alternate ratings and consumers for the same physical fuse position, depending on the engine or model year.
Use the original fuse type and the rating specified for the exact car. A repeatedly blowing fuse requires checking the protected components and wiring.